Redmax CHT2301 User Manual

The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. WA

❲10❳ BEFORE STARTING THE ENGINE1. The area within a perimeter of 50 feet (15m) ofthe person using the product should beconsidered a hazardous area in

Never place the throttle into the high speedposition when starting the engine.3. After starting the engine, check to make surethat the cutting attachm

❲12❳• IF SOMEONE COMES1. Guard against hazardous situations at all times.Warn adults to keep pets and children awayfrom the area. Be careful if you ar

5. For safe operation HANDLING FUEL1. The engine of the RedMax product is designedto run on a mixed fuel which contains highlyflammable gasoline. Nev

❲14❳• Gasoline is very flammable. Avoid smokingor bringing any flame or sparks near fuel.Make sure to stop the engine and allow itcool before refueli

container to avoid mixing up with gasoline orother containers.6. Indicate the contents on outside of container foreasy identification. FUELING THE U

❲16❳ STARTING ENGINEThe cutting head will start rotating upon theengine starts.1. Rest the unit on a flat, firm place. Keep thecutting head off the g

7. Operation1. When restarting the engine immediately afterstopping it, leave the choke open.2. Overchoking can make the engine hard to startdue to ex

• Weather conditions and altitude may effectcarburation.• Do not allow anyone to stay close to thehedge-trimmer while working or whileadjusting the ca

7. OperationOP8OP10OP11OP9❲19❳HEDGE TRIMMING TECHNIQUESTrim sides of a hedge first, and then the top.Vertical cut: • With the single-sided blade hedge

❲20❳8. Maintenanceevery every every25 50 100system/compornent procedure before hours hours hours noteuse after after afterfuel leaks, fuel spillage wi

• Make sure that the engine has stopped and iscool before performing any service to themachine. Contact with moving cutting heador hot muffler may res

❲22❳ MUFFLER• Inspect periodically, the muffler for loosefasteners, any damage or corrosion. If any signof exhaust leakage is found, stop using thema

8. Maintenance BLADESOil blades each gas tank filling (MA5).• Make sure that the blade bolts are welltightened.• The blade assembly is designed toaut

10. Troubleshooting guideCase 1. Starting failure CHECK PROBABLE CAUSES ACTIONfuel tank ➞ incorrect fuel ➞ drain it and with correct fuelfuel filter ➞

11. Parts list ❲25❳NOTE : 1. Use KOMATSU ZENOAH genuine parts as specified in the parts list for repair and/orreplacement. 2. KOMATSU ZENOAH does not

11. Parts list ❲26❳Fig.1 CUTTING UNIT HT2301 (S/N 100101 and up)

Key# Description Part Number Q'ty1 SCREW 3960067 52 HANDLE 58040143 13 NUT 3980014 44 PLATE 58040057 25 SWITCH GUARD 2317013 16 CLUTCH DRUM 58040

Fig.2 ENGINE UNIT HT2301 (S/N 100101 and up)❲28❳11. Parts list

❲29❳Fig.2 ENGINE UNIT HT2301 (S/N 100101 and up)Key# Description Part Number Q'ty Note1 Cylinder 5602-12110 12 Gasket, base 5500-12213 13 Bolt,

SAFETY FIRSTInstructions contained in warnings within thismanual marked with a symbol concerncritical points which must be taken intoconsideration to

11. Parts list ❲30❳Fig.3 CUTTING UNIT CHT2301 (S/N 100101 and up)

Key# Description Part Number Q'ty1 SCREW 3960067 72 FRONT HANDLE 58040185A 13 NUT 3980014 44 PLATE 58040057 25 SWITCH GUARD 2317013 16 CLUTCH DRU

Fig.4 ENGINE UNIT CHT2301 (S/N 100101 and up)❲32❳11. Parts list

❲33❳Fig.4 ENGINE UNIT CHT2301 (S/N 100101 and up)Key# Description Part Number Q'ty Note1 Cylinder 5602-12110 12 Gasket, base 5500-12213 13 Bolt,

The California Air Resources Board and KOMATSU ZENOAH are pleased to explain theemission control system warranty on your 1995 and later small off-road

EMISSION-RELATED PARTS, FOR TWO (2) YEARS FROM THE DATE OF ORIGINAL DELIVERY, KOMATSU ZENOAHAMERICA INC. (THE COMPANY), THROUGH ANY RedMax DEALER, WI

Pièces en rapport avec les émissions de gaz d'échappement : KOMATSU ZENOAH AMERICA INC., parl'intermédiaire de n'importe quel revendeur

1. Parts location❲4❳1. Right handle2. Fuel tank3. Starter4. Left handle5. Throttle lever6. Ignition switch7. Throttle Cable8. Muffler9. Blade10. Front

2. SpecificationsEngine Type······················································································ Air-cooled 2-stroke gasolineModel··

❲6❳(1) Read owner's manual before operating this machine.(2) Wear head, eye and ear protection.If warning label peel off or become soiled and imp

For safe operation and maintenance, symbols arecarved in relief on the machine. According to theseindications, please be careful not to make amistake.

❲8❳5. For safe operation1. Read this manual carefully until youcompletely understand and follow all safetyand operating instructions. 2. Keep this man

b. At night, at times of heavy fog, or at any othertimes when your field of vision might belimited and it would be difficult to gain a clearview of th