Redmax EBZ5000 User Manual

OWNER/OPERATOR MANUALMANUAL DEL PROPIETARIO/OPERADORBACKPACK BLOWERSOPLADOR DE MOCHILA848-L3B-93A1 (501)EBZ5000/EBZ5000RHAPPLICABLE SERIAL NUMBERS: 30

EspañolEnglish101. Frame2. Shoulder Strap3. Spark Plug Cap4. Throttle Lever5. Ignition Switch (behind)6. Net7. Choke Lever8. Air Cleaner9. Volute Case

11EspañolEnglishSpecificationsPosición de las piezas y especificacionesMODEL EBZ5000/EBZ5000RHDimensions (L x W x H) mm (in)...

EspañolEnglish12 BLOWER TUBES1. Connect the blower and swivel joint withflexible hose. Clamp both ends of theflexible hose securely with the hardware

EspañolEnglish FUEL• Gasoline is very flammable. Avoidsmoking or bringing any flame orsparks near fuel. Make sure to stopthe engine and allow it cool

14EspañolEnglish HOW TO MIX FUELPay attention to agitation.1. Measure out the quantities of gasolineand oil to be mixed.2. Put some of the gasoline i

15EspañolEnglishFuel Combustibleof rubber and/or plastic parts anddisruption of engine lubrication.3. OIL FOR 4-CYCLE ENGINE USE – Itcan cause spark p

16EspañolEnglish CONTROL ARM [EBZ5000]• Hold the upper end of the control arm inhand and, while pulling it away from theunit, rotate arm forward (ant

EspañolEnglish5. Once the engine is running, graduallyopen the choke if it was set closed, andlet the engine run at idle speed for aminute to warm it

18EspañolEnglishMake sure that the engine has stoppedand is cool before performing anyservice to the blower. Contact withrotating blower fan or hot mu

EspañolEnglishSet the packing into the air cleanerbody. Set the cover with 2 fixingscrews. (1) Cover Cleaner (5) Packing(2) Screen (6) Yellow(3) Clean

EspañolEnglishLA SEGURIDAD PRIMEROLas instrucciones que se dan en lasadvertencias contenidas en este manual yen las etiquetas de advertencia marcadasc

20EspañolEnglish• Note that using any spark plugs otherthan those designated may result in theengine failing to operate properly or inthe engine becom

EspañolEnglish AIR INLET NET• Blowing air is taken in from the air inletnet. When air flow has dropped downduring operation, stop the engine andinspe

BEFORE STORING THE BLOWER:1. Drain a fuel tank and push the primerbulb until it becomes empty of fuel.2 .Remove the spark plug and drop aspoonful of 2

23PARTS LIST LISTA DE PIEZASNOTE: 1. Use KOMATSU ZENOAH genuine parts asspecified in the parts list for repair and/orreplacement. 2. KOMATSU ZENOAH do

24Parts List : EBZ5000/EBZ5000RHFig.1 BLOWER GROUP (S/N 300001 and up)

25EBZ5000/EBZ5000RHFig.1 BLOWER GROUP (S/N 300001 and up)Key# Part Number Description Q'ty1 T4017-31110 VOLUTE CASE 12 848-L36-55B0 VOLUTE COVER

26Parts List : EBZ5000/EBZ5000RHFig.2 ENGINE GROUP (S/N 50100000 and up)

27EBZ5000/EBZ5000RHFig.2 ENGINE GROUP (S/N 50100000 and up)Key# Part Number Description Q'ty1 T1108-12110 CYLINDER 12 T1108-12210 GASKET, BASE 13

Key# Part Number Description Q'ty1 T1108-81450 Body assy 12 ————— Screen 13 ————— Valve 14 ————— Spring 15 ————— Screw 16 ————— Pin 17 ————— Leve

29Parts List : EBZ5000/EBZ5000RH123456789101112131415161718192021122Fig.4 LEVER SET [EBZ5000](S/N 300001 and up)Fig.5 LEVER (R) SET [EBZ5000RH](S/N 30

EspañolEnglishContenido3ContentsSAFETY PRECAUTIONS …………………………………………4OPERATORUSE OF BLOWERFUELWORKING CONDITIONAVOID NOISE PROBLEMAVOID CHANCES OF DAMA

EMISSION-RELATED PARTS, FOR TWO (2) YEARS FROM THE DATE OF ORIGINAL DELIVERY OF THE UNIT, KOMATSU ZENOAH AMERICA INC. (THE COMPANY), THROUGH ANY RedMa

PIEZAS REALACIONADAS CON LAS EMISIONES, POR DOS (2) AÑOS A CONTAR DE LA FECHA DE ENTREGA ORIGINALDEL UNIDAD, KOMATSU ZENOAH AMERICA INC. (LA COMPAÑÍA)

Pièces en rapport avec les émissions de gaz d'échappement : KOMATSU ZENOAH AMERICA INC., parl'intermédiaire de n'importe quel revendeur

EspañolEnglish4• Read this Blower Owner/OperatorManual carefully. Be sure youunderstand how to operate thisunit properly before you use it.Failure to

5EspañolEnglishsure to check if any obstacles are leftinside the volute case. The obstaclesmay cause damage on fan and volutecase and serious injury.(

EspañolEnglish6 FUELTo reduce the risk of fire and burninjury:• Handle fuel with care. It is highlyflammable.• Do not smoke while handing fuel.• Do n

7EspañolEnglish AVOID NOISE PROBLEMCheck and follow the localregulations as to sound level andhours of operations for blower. • Operate power equipme

EspañolEnglish8(1) Read owner's manual beforeoperating this machine.(2) Wear head, eye and ear protection.(3) Handling this machine improperlycou

9EspañolEnglishFor safe operation and maintenance,symbols are carved in relief on themachine. According to these indications,please be careful not to